# Introduction itric acid is one of the world's largest tonnages of fermentation products. It is widely used in the food beverage industries as an acidifying and flavor-enhancing agent, pharmaceutical, chemical, cosmetic and other industries for applications such as acidulation, antioxidation, flavor enhancement, preservation, plasticizer and as a synergistic agent. The worldwide demand for citric acid is met by fermentation mainly by the process involving the filamentous fungus A. niger. A number of carbon sources may be used for citric acid fermentation. For commercial reasons, the uses of molasses, sucrose or glucose syrups are favored. The use of molasses in particular is desirable because of its low cost availability. A. niger is capable of producing very high levels of citric acid, about 90% of the theoretical yield from a carbohydrate source. For an efficient citric acid production, the growth of Aspergillus in pellet form is desirable and this can be achieved by process optimization. There is a great worldwide demand for citric acid consumption due to its low toxicity compared with other acidulants used mainly in the pharmaceutical and food industries. Global production of citric acid has now reached 1.4 million tones and there is annual growth of 3.5-4.0 % in demand/consumption. A high rate of acidogenesis in A. niger is observed only under conditions of high glycolytic metabolism and can be induced by the addition of an excess amount of sucrose or other carbohydrates which induce a high rate of glycolytic catabolism. In this production technique, which is still the major industrial route to citric acid used today, cultures of Aspergillus niger are fed on a sucrose or glucose-containing medium to produce citric acid. The source of sugar is corn steep liquor, molasses, hydrolyzed corn starch or other inexpensive sugary solutions. Bangladesh, at present, imported cent percent citric acid from foreign countries. High production depends to a great extent on the strain used and its response to the composition of the medium can show a great deal of variability. Industrial production of this chemical by fermentation using cheap raw materials is helpful in economic development of our country. Keeping in view the future requirements and also the availability of cheap raw material, efforts were made to develop the process for citric acid fermentation, based on our local resources such as molasses from sugar mills and outer portion of jackfruit. So the purpose of present study describes the feasibility of using raw and cheap materials such as molasses and outer portion of jackfruit for citric acid fermentation and to use parent strain CA16 & gamma-ray induced mutants for high citric acid yielding strain 79/20 of Aspergillus niger. Aspergillus niger is a haploid filamentous fungi and is a very essential microorganism in the field of biology. A. niger is cultured for the industrial production of many substances. Various strains of A. niger are used in the industrial preparation of citric acid (E330) and gluconic acid (E574) and have been assessed as acceptable for daily intake by the World Health Organization. A. niger is important because of its involvement in producing citric acid as well as industrial enzymes, such as amylases, proteases, and lipases. The uses of these enzymes are essential because of its importance for transformation to food enzymes. For example, A. niger glucoamylase is used in the production of high fructose corn syrup, and pectinases are used in cider and wine clarification. Glucose oxidase is used in the design of glucose biosensors, due to its high affinity for ?-D-glucose. A variety of carbohydrate sources such as beet molasses, cane molasses, sucrose, commercial glucose, starch hydrolysates etc., have been used for citric acid production. Among these, sucrose, cane and beet molasses have been found to be the best choice (Kapoor et al., 1982). # II. # Materials and Methods This study was done in the research laboratory of the Department of Biochemistry and Molecular Miology at Jahangirnagar University and at Institute of Food and Radiation Biology, Atomic Energy Research Establishment, Bangladesh during July 2009 and June 2010. Parent strain Aspergillus niger CA16 and mutant strain Aspergillus niger 79/20 were first grown on agar slant medium. Each of the properly processed substrates [Molasses, jackfruit (outer potion) and mixed substrates] was hydrolyzed by 0.05 N HCl and filtered which were then used as medium for submerged fermentation. Each substrate were divided into two groups and were fermented separately, one in the presence of Prescott salt and the other in the absence. Each of the groups of the three types of media were further divided into another two subgroups and one of them was inoculated with the parent strain Aspergillus niger CA16 and the remaining one was inoculated with the mutant strain Aspergillus niger 79/20. All the flasks were then incubated for 15 days in an incubator under same conditions. Fermented media were collected on day 3, 6, 9, 12, 15 and were subjected to estimation of residual sugar, TTA value, citric acid concentration and pH determination. # III. # Chemical Reagents and Solutions All chemicals and reagents used in this study were of analytical grade. All aqueous solutions were prepared with distilled water. Stock solution of Prescott salt (NH4NO3: 2.23g/L, K2HPO4: 1.00g/L, MgSO4.7H2O: 0.23g/L) used in the media were prepared 10 times the media concentration and diluted as its normal strength in the experiment. # IV. # Analytical Determination At the different stages of fermentation the culture flasks were taken out of the incubator and the medium was collected onto the screw cap test tubes by pipetting and preserved at 0oC. The appropriate amount of sample was used for the estimation of total titratable acidity, citric acid and amount of residual sugar present in the medium after fermentation. # V. Determination of total Titratable Acidity (TTA) Fermented medium (0.25ml) was diluted with 20ml of distilled water and was titrated against 0.1N NaOH solution using 2 to 3 drops of phenolphthalein as indicator. The value obtained was multiplied by 4 and total titratable acidity was expressed as ml of 0.1N NaOH required to neutralize 1ml fermented medium. The titrametric analysis of fermentation of each strain gave an indication of total acidity of the medium. The medium containing high TTA value i.e. higher acid content were then analyzed spectrophotometrically. # VI. # Estimation of citric Acid from Fermentation Medium Citric acid was estimated spectrophotometrically by the reference method of Marier and Boulet (1958). Citric acid forms a color complex of polyvinyl keto-anhydridepolymer when it reacts with acetic anhydride and pyridine which can be estimated spectrophptometrically (Auterhoff and Schwingel, 1975). Following the growth of the organism aliquots of the medium were diluted so as to have concentration in the range of 25 # Estimation of Residual Sugar Before inoculation and after completion of fermentation, samples were collected for initial and residual sugar estimation, respectively. Following the fermentation, amount of residual sugar in the medium was determined by diluting the aliquots of the medium so as containing sugar concentration range of 25-200?g per ml. Initial and residual sugar of the medium was determined spectrophotometrically by anthrone method (Morse, 1947) using anthrone as the coloring agent with sucrose as standard. # VIII. # Results # a) Estimation of residual sugar at different periods of citric acid fermentation The residual sugar concentration was different in various media during citric acid fermentation by These results showed TTA value was comparatively higher in the absence of Prescott salt for all the three types of media and for each of the stain. Throughout the incubation period the TTA value was highest in case mixed fermentation medium followed by molasses and jackfruit fermentation medium. Again, fermentation by Aspergillus niger 79/20 resulted in a comparatively higher TTA value than by Aspergillus niger CA16 both in the presence and absence of Prescott salt (Figure 19). # c) Estimation of citric acid accumulation at different period of citric acid fermentation Accumulation of citric acid at different incubation periods on different media followed a very similar pattern as was seen in case of TTA value. Citric acid concentration was also different on different incubation periods with various fermentation media by the parent strain Aspergillus niger CA16 strain and the mutant strain 79/20. Citric acid concentration was found to increase gradually with the increase of incubation period and maximum citric acid concentration was found on day 12 in case of each of the three media. These results showed citric acid concentration was comparatively higher in the absence of Prescott salt for all the three types of media and for each of the strain. Throughout the incubation period the citric acid concentration was highest in case mixed fermentation medium followed by molasses and jackfruit fermentation medium. Again, fermentation by Aspergillus niger 79/20 resulted in a comparatively higher citric acid accumulation than by Aspergillus niger CA16 both in the presence and absence of Prescott salt (Figure -22). Fermentation of citric acid for commercial production is dependent on many factors like quality of strains, nutritional composition of the media, environmental conditions, deficiency of manganese and other metals, pH, temperature and dissolved oxygen tension . Usually, Aspergillus niger gives the best yield at around 25-28ºC. Increase in incubation period resulted in the increased citric acid production. A lower concentration of sugar leads to lower yield of citric acid as well as accumulation of oxalic acid (Kovats, 1960). But the use of wild type strain of Aspergillus niger is not cost effective. So, high yielding strains were searched which will give the best yield at around the room temperature. The superior strains Aspergillus niger CA16 and gamma ray induced mutants Aspergillus niger 79/20 seem to have fulfilled the requirement. Thus these strains can be conveniently exploited for the production of citric acid from cane molasses, jackfruit (outer portion) and a mixture of the two substrates. From the findings of this study it is clearly suggested that both fermentation medium and Prescott salt have a considerable effect on the production of citric acid. Among the media used in this study, the mixed fermentation medium was found to be most suitable for citric acid production followed by molasses and jackfruit (outer portion) media. Another important finding of the present study was that Prescott salt was found to have a negative effect on the citric acid production by the either strains of Aspergillus niger. Again the gamma-ray induced mutant strain, Aspergillus niger 79/20 had a yield efficiency more than that of the parent strain Aspergillus niger CA16 and thus considered superior to the parent strain Aspergillus niger CA16. Thus as far as citric acid production is ![to 200?g per ml (approximately) of citric acid. Year 2017 Optimization of Citric Acid Production by Substrate Selection using Gamma Ray Induced Mutant Strain of Aspergillus niger VII.](image-2.png "C") ![15 on molasses fermentation medium by Aspergillus niger CA16 in the absence of Prescott salt (Figure-15). Residual sugar found in the molasses fermentation medium by Aspergillus niger 79/20 on day 3, 6, 9, 12 and 15 was 35.64, 29.62, 21.98, 16.20 and 11.51 mg/ml respectively, in the presence of Prescott salt and 40.12, 34.41, 30.13, 25.55 and 17.51 mg/ml respectively in the absence of Prescott salt. At Day 15 lowest amount of residual sugar was found on molasses fermentation medium by Aspergillus niger 79/20 in the presence of Prescott salt which is higher than that found by Aspergillus niger CA16 in the absence of Prescott salt (Figure-14 & 15).](image-3.png "") 14![Figure 14: Amount of Residual Sugar at different days of fermentation in various substrate (with Prescott salt) by A. niger CA16 and mutant strain A. niger 79/20.](image-4.png "Figure 14 :") 15![Figure 15: Amount of residual sugar at different days of fermentation in various substrates (Without Prescott salt) by A. niger CA16 and mutant strain A. niger 79/20. When Aspergillus niger CA16 used jackfruit (outer portion) as fermentation medium, the residual sugar found on day 3, 6, 9, 12 and 15 in presence of Prescott salt was 30.34, 24.34, 20.04, 16.78 and 12.32](image-5.png "Figure 15 :") 16![Figure 16: Amount of residual sugar at day 12 of fermentation in different substrates (with and without Prescott salt) by A. niger CA16 and mutant strain A. niger 79/20. Here, P & A indicates presence & absence of Prescott salt respectively.](image-6.png "Figure 16 :C") 17![Figure 17: TTA values at different days of fermentation in different substrates (with Prescott salt) by Aspergillus niger CA16 and mutant strain Aspergillus niger 79/20.](image-7.png "Figure 17 :") 18![Figure 18: TTA values at different days of fermentation in different substrates (without Prescott salt) by Aspergillus niger CA16 and mutant strain Aspergillus niger. In the presence of Prescott salt, TTA value found in the jackfruit (outer portion) fermentation medium by Aspergillus niger CA16 on day 3, 6, 9, 12 and 15 was 0.2, 0.5, 1.2, 1.5 and 1.3 respectively and that in the absence of Prescott TTA value found was 0.3, 0.96, 1.5, 2.68 and 2.16 respectively. Highest TTA value was found at Day 12 on jackfruit fermentation medium by Aspergillus niger CA16 in the absence of Prescott salt. When Aspergillus niger 79/20 was the strain used for fermentation on jackfruit medium, the TTA value found in the presence of Prescott salt on day 3, 6, 9, 12 and 15 was 0.8, 1.2, 2.1, 2.9 and 2.5 respectively and in the absence of Prescott salt was 1.0, 2.1, 3.2, 4.6 and 4.22. TTA value was highest at day 12 in the absence of Prescott salt for Aspergillus niger 79/20 which was higher than that obtained for Aspergillus niger CA16 (Figure-17 & 18).TTA value obtained on day 3, 6, 9, 12 and 15 was 0.3, 0.95, 1.6, 2.4 and 1.67 respectively in the presence of Prescott salt and in the absence of Prescott salt was 0.5, 1.2, 2.8, 3.4 and 2.85 respectively when the parent strain Aspergillus niger CA16 was allowed to ferment the mixed medium. Highest TTA value found in the absence of Prescott salt for Aspergillus niger CA16 grown on mixed fermentation medium. When the same medium was fermented by Aspergillus niger 79/20, the TTA value obtained in the presence of Prescott salt on day 3, 6, 9, 12 and 15 was 1.0, 1.89, 2.9, 3.4 and 2.95 respectively and in the absence of Prescott salt the TTA value was 1.2, 2.7, 3.95, 5.38 and 4.89 respectively. Once again the highest TTA value was obtained for Aspergillus niger 79/20 on day 12 in the absence of Prescott salt which was higher than that obtained in case of Aspergillus nigerCA16 (Figure-17 & 18).](image-8.png "Figure 18 :C") 19![Figure 19: Total Titratable Acidity at day 12 of fermentation in different substrates (with and without Prescott salt) by A. niger CA16 and mutant strain A. niger 79/20. Here, P & A indicates presence & absence of Prescott salt respectively.](image-9.png "Figure 19 :") ![Finally, citric acid concentration was found to decrease at day 15 [(Figure-20, 21 & 22) and (Appendix-III & VI)].](image-10.png "") Volume XVII Issue II Version ID D D D )(Medical ResearchGlobal Journal of © 2017 Global Journals Inc. (US) © 2017 Global Journals Inc. (US) Year 2017 (Figure-20 & 21). © 2017 Global Journals Inc. (US) * Ochratoxin: A production by strains of Aspergillus niger var, niger MAbarca MBragulat GCastella FCabanes Appl Environ Microbiol 60 7 1994 * Biosynthesis of citric acid by locally isolated Aspergillus niger using sucrose salt media SAli Ikram-Ul-Haq MAQadeer JIqbal J, Biol. Sci 1 4 2001 * Citri acid. Biochemical Engineering and Biotechnology hand book BAtkinson FMavitane 1983 The nature press New York * Reaction of citric acid with acetic anhydride and pyridine HAuterhoff ISchwingel Archiv. Der Phannazic 308 8 583 1975 * Fermentive production of citric acid by Aspergillus niger. Selection optimum cultural conditions for improved citric acid production AKBanik J. Food. Sci. Technol 12 1975 * Effect of addition of methanol in molasses medium on the production of citric acid by Aspergillus niger AABegum NChoudhury MSIslam Bangladesh J. Microbiol 5 1 1988 * Citric acid fermentation by gamma-ray induced mutants of Aspergillus niger in sugarcane and jack fruit juice RBegum NChoudhury Bangladesh J. Life Sci 10 1&2 1998 * Citric acid fermentation in different starchy substrates by radiation induced mutants of Aspergillus niger RBegum NChoudhury J. Asiat. Soc. Bangladesh. Sci 26 1 2000 * Citric acid production from Indian cane molasses by Aspergillus niger under solid state fermentation condition KChaudhary SEthiraj KLakshminarayana PTauro J. Ferment. Technol 56 5 1978 * Kinetic studies on citric acid production by Aspergillus niger II. The two stage process AChmiel Microbiologia potonica. Ser Br 7 24 1975 * Kinetic of citric acid production by preculturated mycelium of Aspergillus niger AChmiel Trans. Br. Mycol. SOC 68 3 1977 * Specific effects of mutagens on Aspergillus niger in producing citric acid ADas PNandi Folia Microbiol 17 1972 * The fermentative production of citric acid and oxalic acids from gur and molasses GCDas-Gupta KCShaha BCGuha J. Science and Culture India 3 7 1938 * Effects of interruptions to the air supply on citric acid production by Aspergillus niger MDawson WMaddox ISBrooks J J. Enzyme Microb. Technol 8 1 1986 * Citric acid fermentation WPDoelger SCPrescolt Ind. Eng, Chem 26 1934 * Citric acid production by Aspergillus niger on surface culture on inulin Cr &Drysdale MHMckay Lett Appl Microbiol 20 1995 * Citric acid production from whey with sugars and additives by Aspergillus niger Ma &El-Holi KSAl-Delaimy Afr J Biotechnol 2 10 2003 * Mierobial preparation of citric acid HFukuda TSuzuki YSumino SCAkiyama Ger. Pat 331 1970. 2003 * Production of citric acid by mutants of JFGardner LValeric-James SDRubbo 1956 * Aspergillus Niger. J. Gen. Microbiol 14 * A solid state fermentation of apple pomace for citric acid production using Aspergillus niger YDHang EEWoodams J. Appl. Microbial Biolechnol 2 2 1984 * Citric acid fermentation of brewery waste YDHang DFSplittstoesser EEWoodams RMSherman J. Food Sci 42 2 1977 * Production of citric acid from corncobs by Aspergillus niger YDHang EEWoodams Biores. Technol 65 1998 * Varients of Aspergillus niger induced by gamma rays MAHannan Ind. J. Expt. Biol 10 1972 * Analysis of some mutants of Aspergillus niger for citric acid production MAHannan FRabbi AT MRahman NChoudhury J. Ferment.Technol 51 8 1973 * Stepwise mutational improvement of Aspergillus niger for citric acid productivity in case of molasses MAHannan MGSarwar ABaten NChoudhury J. Folia Microbiol 51 1976 * Direct production of citric acid from corn starch by Aspergillus niger IHaq SAli J Process Biochem 38 2003 * Genetic recombination through protoplast fusion in Streptomyces DAHopwood HMWright MJBibb SMCohen Narture 268 171 1977 * Citric acid fermentation by some gamma ray induced mutants of Aspergillus niger use of Agro industrial residues and cassava as substrates DHossain 1970 Dept. of Microbiology, University of Dhaka M.Sc. Thesis * Citric acid fermentation by mutant strain of Aspergillus niger GCMC-7 using molasses based medium AliIkram-Ul-Haq SQadeer MIqbal J EJB Electronic Journal of Biotechnology 0717-3458 2002 * Semipilot scale production of citric acid in cane molasses by gamma-ray induced mutants of Aspergillus niger MSIslam RBegum NChoudhury Enzyme Microbial Technol 8 1986 * Citric acid is produced industrially by Aspergillus niger Johnson Medical hypothesis 60 2003 * Citric acid. In prescott and Dunn's. Industrial Microbiology, 4 th Ed KKapoor KChandhary KTauro P G. Reed 1982 3 * Studies on method of citric acid fermentation from molasses by Aspergillus niger MA AKhan MMHussain SM AKhalique MARahman Pak. J. Sci. Ind. Res 13 4 19750 * Studies on submerged citric acid fermentation JKovats Acta. Microbiol 9 1960 * BKristiansen MMattey JLinden Citric Acid Biotechnology 1999 Taylor & Frances Ltd * Utilization of fruits waste for citric acid production by solid state fermentation DKumar VKJain GShanker ASrivastava J. Process Biochem 38 12 1731 2002 * A solid state fermentation method for citric acid production using sugarcane bagasse KLakshminarayana KChaudhary SEthiraj PTauro 1975 * J. Biotechnol. Bioeng 27 * Citric acid and itaconic acid fermentation LBLockwood LB. ; HSchweiger Microbiol. Technology 1967 * JPp * Production of citric acid from waste bread by Aspergillus niger AKLodhi MAsghar MZia AArnbreen SAsad MJ J. Biol. Sci 1 4 2001 * Citric acid production by Aspergillus niger in solidsubstrale fermentation MYLu ISMaddox JBrooks D Bioresource Technol 54 3 1995 * Production of citric acid from sugars present in wood hemicellulose using Aspergillus niger and Saccharomycopsis lipolytica ISMaddox KSpencer JMGreenwood MDawson \vBrooks JD J. Biotechnol. Lett 7 851 1985 * Citric acid from potatoes by fermentation SMasior JSurminski JAbranik 1968 Prezemysl * RonyFermentae Junyi 12 * Citric acid production by Aspergillus niger on surface culture on inulin MHMckay CRDrysdale Lett Appl Microbiol 20 1995 * Anthrone in estimating low concentration of sucrose EEMorse Anal. Chem 19 1947 * Effect of alcohols on the mycological production of citric acid in surface and submerged culture AJMoyer Nature of the alcohol effect 1953 * Appl. Microbiol 1 * Effect of alcohols on the mycological production of citric acid in surface and submerged culture. II. Fermentation of crude carbohydrates AJMoyer Appl. Microbiol 1 1953 * Effects of menthol and ethanol on the production of citric acid from cane molasses YNoguchi YBanido 1960 38 Hakko Kogaku zusshi * Studies on citric acid production by Aspergillus niger using treated cane molasses TPanda SKundu SKMajumdar J. Process Biochem 87 1984 * The citric acid fermentation SCPrescott CGDunn Industrial microbiology 1959 3rd edition * London SCPrescott CGDunn Industrial Microbiology 1987. August CBS Publishers and Distributors Mcraw Hill book company. Inc. New York Toronto 4th edition * Industrial strain improvement : Mutagenesis and random screening procedures RTRowalands 1984 * Enzyme. Micro. Technol 6 * Effect of cultural conditions on citric acid production by Aspergillus niger AJ 117173 in surface culture fermentation. Dhaka Univ MLSaha YSakai FTakahashi J. Biol. Sci 15 2 2006 * Isolation and characterization of Aspergillus niger mutants for high yield of citric acid from cane molasses MGSarwar 1973 Bangladesh Dept. of Microbiology, University of Dhaka M. Sc. Thesis * Comparison of citric acid from beet molasses and date syrup with Aspergillus niger. Hakko Hogaka DShadafza TOgawa AFazeli Zasshi 54 1976 * Effect of the composition of the sporulation medium on citric acid production by A. niger in submerged culture PShu MJohnson J. Bacteriol 54 1947 * Citric acid by fermentation RLSnell LBSchweiger British Patent 653 8719 1951 Chem Abstr. * Modeling approach to control carbohydrate metabolism during citric acid accumulation by Aspergillus niger: I. Model definition and stability of the steady state NVTorres Biotechnol and Bioeng 44 1 1994 * Production of citric acid by submerged culture SUsami Mem School Sci. Eng. Waseda Univ 42 1978 * Citric acid production by solid state fermentation method using sugar cane bagasse and concentrated liquor of pineapple waste SUsami NFukutomi Hakkokogaku 55 1977 * Improvement of citric acid production by Aspergillus niger with addition of phytate to beet molasses JWang Bioresource Technol 65 3 1998 * As quoted in: Industrial microbiology CWehmer S. C. Prescott C. G. and Dunn 1893. 1959 * Citric acid production by Aspergillus niger on corn Distillers' grains with solubles GXie TPWest Research J. Microbiol 1 3 2006 McGraw Hill Book Co * Citric acid production by Aspergillus niger on condensed corn distillers solubles GXie TPWest Research J. Microbiol 2 5 2007 * The influence of type and concentration of carbon source on production of citric acid by Aspergillus niger DPXu CPMadrid MRöhr CPKubcek Appl Microbiol Biotechnol 30 1989 * Direct fermentation of citric acid from highly concentrated sweet potato mash: The strain selection of Zhu Heng QinfanyHou 1981 * Aspergillus niger 506 J. Acta. Microbiol. Sin 21 3